Suzuki Ozark 250 (LT-F250) ATV repair manual, also termed service manual or workshop manual. DOWNLOAD 2002-2009 Suzuki Ozark 250 Repair Manual (LT-F250) 2003 Suzuki Ozark 250- 250cc 4 stroke, E-start, 5 speed auto-clutch with reverse, shaft drive and winch.40+ Pre-owned ATV's in stock (Grizzly Big Bear YFZ YFZ450 TRX TRX450R Kodiak King Quad. I have two 2003 Suzuki Ozark 250s, both 2-wheel drive. 2005 Sportsman 6X6 Service Manual 2005 Sportsman 400,500.600 and 700 Owners Manual.
- This 2006 Suzuki LT80 ATV INSTANT REPAIR MANUAL DOWNLOAD was designed primarily for 2006 Suzuki LT80 factory service technicians in a properly equipped shop.However, enough information in this 2006 Suzuki LT80 manual is given for do-it-yourself mechanics to correctly and safely perform repair work to their 2006 Suzuki LT80 ATV.
- 2005 Suzuki LT-F250 Ozark Wheels BikeBandit.com offers thousands of 2005 Suzuki LT-F250 Ozark parts to repair or restore your 2005 Suzuki LT-F250 Ozark to original factory condition and increase its resale value.
- Forum Main Tech Help/Race Shop 2005 Suzuki Ozark 250 carb problem. Take the fuel valve to a older larger dealer and see if they can find a manual fuel valve from.
7/24/2014 12:46 PM
Edited Date/Time:7/24/2014 12:47 PM
I purchased it used. Ran great and was just serviced. Used it for over a year. Then I let the 4 wheeler sit for a year. I can open the air box and it be dry, then start for one minute and wont idle, and air box will have a half inch of gas in the air box. Any one have experience with this 4 wheeler that would be willing to give some info on? I used it at a moto track for flaggers to get around. That is why i want it back running again. Any info would be great! Thanks
Float stuck? or not sealing?
Have you cleaned the carb?
Our current fuels leave a heavy deposit inside the carb after it sets for as little as 2 weeks. After a year you will find a lot of crap in the carb.
Paw Paw
I believe this quad has a vacuum operated petcock on the tank. The bladder in the petcock is bad. It is allowing the vacuum line from the intake to pull fuel straight from the tank on the dry side of the petcock. Had it happen years ago on a similar quad.
I agree the petcock is likely your problem. The Suzuki 'on, reserve, Prime' vacuum operated petcock suck. The old 250 and 300 quadrunners were bad about when the diaphragm in the petcock would go bad, gas would run through the vacuum hose witch is on the front side of the carb and would fill the crankcase with gas
2005 Suzuki Ozark 250
I finally cleaned out the card with no change. As iv searched around it looks like you have to go back with a vacuum style petcock. Has anyone been able to go with a standard on off reserve petcock?
I found this on ebay. Says that all you have to do is seal the vacuum port on the carb. If thats the case could i just seal that off with my current petcock?
http://www.ebay.com/itm/Suzuki-Ozark-LTF-250-Replacement-Fuel-Valve-Gas-Petcock-/281441597646?pt=Motors_ATV_Parts_Accessories&hash=item418739f8ce
imoto34 wrote:
I found this on ebay. Says that all you have to do is seal the vacuum port on the carb. If thats the case could i just seal that off with my current petcock?
http://www.ebay.com/itm/Suzuki-Ozark-LTF-250-Replacement-Fuel-Valve-Gas-Petcock-/281441597646?pt=Motors_ATV_Parts_Accessories&hash=item418739f8ce
That wouldn't work if you have a vacuum carb, you would still need a line from the engine to the carb. Most vacuum lines would have a 'T'with a line going to the carb and the other going to the fuel valve. Take the fuel valve to a older larger dealer and see if they can find a manual fuel valve from an older bike and get it. Another way is to find a nipple that you could screw on to the fuel tank then get a in-line fuel valve at a small engine/lawn mower shop.
imoto34 wrote:
I found this on ebay. Says that all you have to do is seal the vacuum port on the carb. If thats the case could i just seal that off with my current petcock?
http://www.ebay.com/itm/Suzuki-Ozark-LTF-250-Replacement-Fuel-Valve-Gas-Petcock-/281441597646?pt=Motors_ATV_Parts_Accessories&hash=item418739f8ce
xnationalwrench wrote:
That wouldn't work if you have a vacuum carb, you would still need a line from the engine to the carb. Most vacuum lines would have a 'T'with a line going to the carb and the other going to the fuel valve. Take the fuel valve to a older larger dealer and see if they can find a manual fuel valve from an older bike and get it. Another way is to find a nipple that you could screw on to the fuel tank then get a in-line fuel valve at a small engine/lawn mower shop.
I ordered the part before i came back to see your post. The seller of the petcock said that he has the same atv and did the same fix, and actually shipped the part to me without me paying until i seen it work for my self! So unless the dude is full of shit or enjoys giving shit away, ill be able to give an update first of the week. I work weekends so i should be able to get to it Sunday afternoon then ill give an update. Its the time here in TN to have a extra four wheeler sitting around
So I have the same problem did the eBay petcock work? Did you have to get a diff petcock with the vacuum side!
2005 Suzuki Ozark 250 Owners Manual
- How and when to perform scheduled maintenance for Suzuki LT-F250 Ozark 2005
- How to diagnose 2005 Suzuki LT-F250 Ozark engine or component problems
- How to perform 2005 Suzuki LT-F250 Ozark troubleshooting operations [i.e. 2005 LT-F250 Ozark engine idles poorly, engine runs rough at high speed, engine lacks power, engine stall easily, slipping clutch, 2005 LT-F250 Ozark engine noises, engine will not start or hard to start, engine overheats on 2005 LT-F250 Ozark, engine running lean etc.]
- How to do engine compression test on 2005 Suzuki LT-F250 Ozark
- How to do testing to 2005 Suzuki LT-F250 Ozark electrical parts
- How to rebuild engine to factory specs
- How to check and test 2005 Suzuki LT-F250 Ozark fuel system and
- How to change oil and correct oil capacity for 2005 LT-F250 Ozark
- How to diagnose no spark issues for 2005 Suzuki 250
- How to disassemble, repair and adjust 2005 Suzuki LT-F250 Ozark steering, linkage and throttle cables.
- How to inspect 2005 Suzuki LT-F250 Ozark pistons, rings, rods, etc and how to replace them.
- how to change a head gasket on a 2005 Suzuki 250
- How to do a complete engine tune-up on 2005 Suzuki LT-F250 Ozark
- How to adjust idle speed.
- How to remove, rebuild and install cylinder head.
- How to disassemble, adjust and tune 2005 LT-F250 Ozark carburetor.
- How to repair stator coil, starter motor and regulator/rectifier.
- Complete wiring diagrams, hose routing, wire colors for 2005 LT F250.
- THIS 2005 Suzuki LT-F250 Ozark MANUAL COVERS ALL ASPECTS OF REPAIR! FROM MAINTENANCE TO COMPLETE ENGINE OVERHAUL.